H-9. LUBRICATION NOTES1. ENGINE CRANKCASE. Check engine oil level daily. Change engine oil at initial 5,000 miles (8,045 km). Duringthe remainder of the 12,000 mile (19,308 km)/18 month warranty period, Units participating in AOAP will change engineoil every 6,000 miles (9,654 km). Units not participating in AOAP, will change engine oil every 6,000 miles (9,654 km)or every six months, whichever occurs first. After expiration of engine warranty period, Units participating in AOAP willperform engine oil change as directed by AOAP. Units not participating in AOAP will change engine oil every 6,000miles (9,654 km) or every six months, whichever occurs first, or when operating in dusty areas or under severeoperating conditions, change the oil every 3,000 miles (4,827 km) or every three months, whichever occurs first. Drainengine oil when engine is warm. Refill engine crankcase with OE/HDO specified for the ambient temperature. Engineoil is full when level is within crosshatch marks on the dipstick. Do not overfill.2. ENGINE OIL FILTER. Filter is replaced each time the crankcase is drained. If water or metal particles aredetected during oil filter replacement, notify Direct Support Maintenance personnel before refilling crankcase.3. TRANSMISSION. Check transmission oil level daily. Change transmission oil at initial 5,000 miles (8,045 km).During the remainder of the 24 month/unlimited mileage warranty, Units participating in AOAP will perform transmissionoil change as directed by AOAP. Units not participating in AOAP will perform transmission oil change every 24,000miles (38,616 km) or once every two years, whichever occurs first. Drain transmission oil when engine is warm. Refillwith OE/HDO specified for ambient temperature. Add oil until the proper level is reached (TM 9-2320-365-10). Do notoverfill. Replace oil filters each time transmission oil is changed.4. POWER STEERING. Check power steering oil level weekly. Change the oil every 24,000 miles (38,616 km).Disconnect upper and lower hoses from steering gear and drain oil. Refill power steering pump reservoir with OE/HDOspecified for the ambient temperature. Reservoir is full when oil is between the two marks on the dipstick. Do notoverfill. Remove dipstick, wipe clean and install dipstick fully into reservoir. Remove dipstick and read oil level.Replace oil filter each time power steering oil is changed.5. FUEL/WATER SEPARATOR. Replace filter element every 6,000 miles (9,654 km) or once every six months,whichever occurs first.6. FUEL FILTER. The fuel particle filter is replaced when a new fuel/water separator filter element is installed. Thenormal replacement interval is every 6,000 miles (9,654 km) or once every six months, whichever occurs first.7. ENGINE COOLANT. Check engine coolant level daily. Change the coolant and flush the cooling system every24,000 miles (38,616 km) or once every two years, whichever occurs first. Fill radiator overflow tank with an EthyleneGlycol/water mixture as specified in 0-A-548D. Service the cooling system before the specified interval if:• Coolant is heavily contaminated.• Engine overheats.• Oil cooler has failed allowing oil and coolant to mix.8. HYDRAULIC RESERVOIR and FILTER. Check oil level weekly and make sure oil level gage reads F (full). Unitsparticipating in AOAP will sample oil annually and change oil and filter as directed by AOAP. Units not participating inAOAP will change oil and filter every two years. Drain oil and refill hydraulic reservoir with OE/HDO specified forambient operating temperature. Fill hydraulic reservoir until oil level gage reads F (full). Do not overfill. Replace oilfilter each time oil is changed.H-17TM 9-2320-365-20-4
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
